[Sirrotica]

Originally Posted by MarkS57

They do and sometime not for the right reasons. Engine fires. Very much overblown. I owned one of the first V6 GT's off the line in early 85. My first new car. It had some issues but man it did turn heads and it was ball to drive (4 spd). I prefer to remember them as another Pontiac Pirate Ship victory, raise the Jolly Roger- damn the torpedoes! full speed ahead! Ha! In your eye 'chebby! Just sayin'...

The 4 cylinders were the ones that had engine fires, not the V6s.

Engine fire reputation

Of the total production of the Pontiac Fiero of 370,168,[1] 135 (.036%) of them were reported to have had engine fires, 122 of these occurred while driving, according to the NHTSA.

The engine fires almost exclusively pertained to the 1984 model year. Later model years were produced with upgraded equipment, and frequency of engine fire was significantly reduced.[citation needed]

According to AutoWeeks publication of Fiero firing squad, on October 6, 1983 a Pontiac engineer wrote an urgent memo to report that two Fieros had suddenly caught fire during test drives. This was only 3 months after the production of the Fiero began at the Pontiac plant. It was thought to be caused by antifreeze leaking out of badly installed hoses but in reality it was defective connecting rods. After one meeting with the Saginaw foundry manager, he wrote that “…60 percent to 90 percent of the rods produced do not exhibit defects.” This means at least every 1 out of 10 rods produced were defective and possibly 4 out of 10 were also defective. The Associated Press quoted the National Highway Traffic Safety Administration as saying it had "...received 148 complaints regarding Pontiac Fieros catching fire including reports of six injuries.... Low levels of engine oil may cause a connecting rod to break, allowing oil to escape and come into contact with engine parts. The oil would catch fire when it contacted the exhaust manifold or hot exhaust components.... David Hudgens, a GM spokesman in Detroit... said, 'If you ran out of oil, and then that coupled with some aggressive driving, perhaps, and maybe not changing the oil very often, you end up with a broken rod, and that's where the connecting rod came in; it is still the owner's responsibility to check the oil.' "[17]

The Pontiac division claimed in a 1988 press release that "GM tests have shown that running these 1984 cars with low engine oil level can cause connecting rod failure which may lead to an engine compartment fire.... Pontiac is aware of 260 fires attributable to the condition, along with ten reported minor injuries."[18]

The larger of the two reported numbers of cars with fires (260) amounts to 0.07% of Fiero models produced. The fires affected the 2.5 L engine almost exclusively, and mostly 1984 models (although there may have been additional occurrences after the above reports were published).

There are several possible contributors to Fiero engines catching fire. The primary cause is thought to be a batch of poorly cast connecting rods, produced in GM's Saginaw plant, which failed when the oil level became too low. One theory is that the sports car styling attracted buyers who would drive the car hard, most notably by excessively revving the engine. Another factor was the incorrectly listed three-quart oil capacity; the actual oil capacity is 4.5 quarts, but a misprint on the dipstick and in the owner's manual resulted in owners using only three quarts, any leakage or consumption would allow the oil level to decline over time to a dangerously low level. If the proper oil level was not maintained, the bearings could seize, snapping the porous castings of the connecting rods. This could result in a hole being punched in the engine block, allowing oil to spray onto hot exhaust components where it could ignite.

Alternatively, some fires may have been because of the engine wiring harness bulkhead connector (C500) being located in the center of the engine bay above the exhaust manifold, where heat could possibly melt and ignite the wiring. The 1984 model had a magnesium grille over this area. In later models, the main engine harness connector (C500) was moved to the battery area, and was improved to some degree with better heat shielding wrapped around the wiring harness.

A third cause might be cracks in the engine block from overtightening the head bolts. Some engines developed cracks in the block that would leak coolant and/or oil, sometimes accompanied by broken head bolts directly above the crack. The leak would spray coolant or oil, the latter resulting in fire if sprayed onto the hot catalytic converter or exhaust manifold at the front of the engine compartment.

Most vehicles existing today have been serviced by GM during one of the safety recalls on the car.[citation needed] For the fire-related recall, shields and drip-trays were added to prevent leaking fluids from contacting hot surfaces. The presence of drip shields between the engine block and the exhaust manifold are a clue that the car has been retrofitted. The addition of the longer AC Delco PF51 oil filter and a re-calibrated dipstick added extra oil capacity to the oiling system, and enabled running four quarts of oil in the crankcase instead of three, to help prevent oil starvation to the rods. Certain vehicles also had their connecting rods or entire block replaced.

Any fires that happen today would most likely not be caused by the aforementioned causes, but instead due to faulty repairs and failure of engine components, wiring, etc. due to age.[citation needed]

I owned an 86 SE 4 cylinder automatic 4 cyl. (daughters first car), tons of people asking WTF I would buy her an unsafe car like a Fiero. Maybe because the Fiero was actually quite a safe car with the passenger compartment surrounded by a full cage structure, if they bothered to look at the design of the car, instead of listening to idiots that don't have a clue. My own 88 was a 4 cyl. 5 speed. Put tons of miles on both of them. The timing gears went out of my 88 at about 130,000, fixed it and kept driving it until I sold it at around 155,000.